Local resistance of fluid flow across sudden contraction in small channels

2010, Volume 4, Issue 2

Abstract

Keywords

Related Research

Frontiers in Energy >> 2010, Volume 4, Issue 2 doi: 10.1007/s11708-009-0060-7

Local resistance of fluid flow across sudden contraction in small channels

Key Laboratory of Enhanced Heat Transfer and Energy Conservation, Ministry of Education of China, College of Environmental and Energy Engineering, Beijing University of Technology, Beijing 100124, China；Key Laboratory of Heat Transfer and Energy Conversion, Beijing Municipality, Beijing University of Technology, Beijing 100124, China;

Available online: 2010-06-05

HTML26 PDF 3 Collect 0

Next Previous

Abstract

The pressure drop caused by flow area contraction in microchannels has been experimentally studied in this paper using the tiny gap pressure measurement method. The working fluid was deionized water at room temperature at near-atmospheric pressure. Three test sections with area ratios of 0.284 and 0.274 and at different tube diameter sizes were used. The experimental results show that the abrupt contraction coefficient decreases with the Reynolds number increasing, and it is much higher than that of conventional tubes in laminar flow. The widely-applied correlation =0.5(1−) could not predict the contraction coefficient of turbulent flow in the micro tubes. The decreases as the tube diameter increases. The transition from laminar to turbulent flow is not obvious when the diameter of the small tube is 0.32mm.

Keywords

microchannels ; pressure drop ; abrupt contraction ; loss coefficients

Related Research